Product ID:COMP B, U-1202-D
MSDS Date:06/01/1993
FSC:8010
NIIN:00-082-2477
Kit Part:Y
MSDS Number: BWRWB

STERLING LACQUER MFG CO, INC

3150 BRANNON AVE
ST LOUIS, MO 63139
US

Emergency Phone: 314-776-4450

Info Phone: 314-776-4450

Preparer: P.D. MOORE

Cage: 60003

STERLING LACQUER MFG CO

ST. LOUIS, MO 63139-1422 US

Telephone: 314-776-4450

Cage: 60003

ISOPROPYL ALCOHOL (SARA III) (VAPOR PRESSURE 30.0 MM HG

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 51%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

2-PROPOXYETHANOL (VAPOR PRESSURE 1.3 MM HG @ 77F)

CAS: 2807-30-9

RTECS: KM2800000

Fraction By Weight: 21%

XYLENE (SARA 313) (CERCLA) (VAPOR PRESSURE 9.5 MM HG @ 68F)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.45 LB/GL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT (NOSE, THROAT, LUNGS) AND/OR NARCOSIS. SKIN & EYE:
IRRITATING, MAY INJURE EYE TISSUE IF NOT PROPERLY REMOVED. SKIN
ABSORPTION: IRRITATION DUE TO SOLVENTS. I NGESTION: TOXIC. MAY
CAUSE NAUSEAA, VOMITING, DIARRHEA. DON'T INGEST. CONSULT PHYSICIAN.
Explanation of Carcinogenicity:CRYSTALLINE SILICA HAS BEEN CLASSIFIED
AS PROBABLY CARCINOGEN FOR HUMANS (2A) BY IARC
Effects of Overexposure:OVEREXPOSURE HAS BEEN FOUND TO CAUSE FOLLOWING
EFFECTS IN ANIMALS. LIVER ABNORMALITIES, KIDNEY, LUNG, SPLEEN
DAMAGE. OVEREXPOSURE HAS BEEN SUGGESTED AS A CAUSE OF THE FOLLOWING
EFFECTS IN HUMANS: LIV ER ABNORMALITIES. INFORMATION IS BELIEVED
ACCURATE. SILICOSIS, NON CANCEROUS LUNG DISEASE.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS CAN BE
INCREASED BY INHALATION OF VAPORS.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED AREA
WITH SOAP AND WATER. INHALATION: MOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENT ION IF NEEDED. INGESTION: DO NOT INDUCEVOMITING. GET
IMMEDIATE MEDICAL ATTENTION. FOR INDUSTRIAL USE. KEEP AWAY FROM
CHILDREN.

Flash Point Method:TCC
Flash Point:54.0F,12.2C
Lower Limits:1.1
Upper Limits:15.8
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE DEMAND WHEN FIGHTING FIRES. USE
WATER FOG NOZZLES TO COOL CLOSED CONTAINER.
Unusual Fire/Explosion Hazard:DO NOT USE WATER. FLAMM LIQ CAN RELEASE
VAPOR (FORM FLAMM MIX AT TEMP AT/ABOVE FLASHPOINT).ELIMINATE &
ISOLATE FROM IGNIT SOURCES. CO2,CO,TOXIC GASES PRODUCED.

Spill Release Procedures:WEAR RESPIRATOR, ABSORB WITH VERMICULITE OR
OTHER ABSORBENT MATERIAL. ELIMINATE ALL IGNITION SOURCES. STOP
SPILL AT SOURCE AND PREVENT SPREADING.

Handling and Storage Precautions:STORE IN DRY AREA. KEEP CONTAINERS
TIGHTLY CLOSED. PROTECT FROM PHYSICAL DAMAGE. EMPTIED CONTAINERS
RETAIN PRODUCT RESIDUES. STORE BELOW 120F.
Other Precautions:STORE LRG QTY IN BLDGS DESIGNED TO COMPLY W/OSHA
1910.106.KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO PREVENT
LEAK.DON'T STORE NEAR HEAT,SPARKS,FLAME.DON'T GET IN EYES.KEEP AWAY
FROM CHILDREN.AVOID SKIN CONTACT.DON'T INGEST.FOR INDUSTRIAL USE

Respiratory Protection:>TLV OF PRODUCT/COMPONENT,NIOSH/MSHA APPRVD AIR
SUPPLY RESPRTR ADVISED IN ABSENCE OF ENVIRONMENTAL CONTROL.OSHA
REGS PERMIT OTHER NIOSH/MSHA RESPRTRS UNDER SPECIFIED
CONDITIONS.SEE SFTY EQUIP SUPPLR.I MPLEMENT ENGINEER/ADMINISTRATIVE
CONTROL
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:WEAR SOLVENT RESISTANT GLOVES
Eye Protection:CHEMICAL SPLASH GOGGLES,SAFETY GLASSES
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR SOLVENT IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER USE, BEFORE
EATING OR SMOKING.
Supplemental Safety and Health

HCC:F2
Boiling Pt:B.P. Text:179 TO 301F
Vapor Density:> AIR
Spec Gravity:0.9 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIBIBLE
Appearance and Odor:CLEAR LIQUID, SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT.
Hazardous Decomposition Products:BURNING CAN PRODUCE CARBON DIOXIDE
AND/OR CARBON MONOXIDE.
Conditions to Avoid Polymerization:AVOID EXCESSIVE HEAT.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION. CONTAMINATED
ABSORBENT MAY BE DEPOSITED IN A LANDFILL IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.